This shows you the differences between two versions of the page.
Both sides previous revision Previous revision Next revision | Previous revision Next revision Both sides next revision | ||
electrical:depth_of_discharge [2023/08/17 20:43] frater_secessus [effect of DoD on battery life] |
electrical:depth_of_discharge [2023/08/17 21:22] frater_secessus [knowing when SoC is 100% (fully charged)] |
||
---|---|---|---|
Line 1: | Line 1: | ||
===== Depth of discharge / State of Charge ===== | ===== Depth of discharge / State of Charge ===== | ||
- | {{ http://popupbackpacker.com/ | + | //Depth-of-discharge// (DoD or DOD) refers to how low a deep cycle battery is taken between [[electrical: |
DoD is the inverse of //State of Charge (SoC)// | DoD is the inverse of //State of Charge (SoC)// | ||
Line 7: | Line 7: | ||
DoD has a **significant impact on longevity of lead deep cycle batteries**.((and, | DoD has a **significant impact on longevity of lead deep cycle batteries**.((and, | ||
- | Note: This information | + | Note: This information is primarily relevant to lead-chemistry batteries. |
+ | |||
+ | |||
+ | ===== knowing when SoC is 100% (fully charged) ===== | ||
+ | |||
+ | |||
+ | With **lead batteries** we know the battery is 100% when | ||
+ | |||
+ | * we are holding Absorption voltage; and | ||
+ | * current acceptance has decreased to 0.02C, or about 2% of the rated capacity | ||
+ | |||
+ | So for a 225Ah Trojan T-105 that might be when current acceptance drops to **4.5A at 14.8v**. | ||
+ | |||
+ | With **lithium batteries** humans might use use amp-counting with [[electrical: | ||
+ | |||
+ | * at moderate charging rates like 0.2C((20A for a 100Ah LFP)) SoC will be ~100% when voltage rises to 14.0v | ||
+ | * at moderate charging rates SoC will be ~100% when voltage rises to 13.8v and we add perhaps 30 minutes of Absorption duration. | ||
+ | * at moderate charging rates and voltages between ≥13.4v and <13.8v SoC will be ~100% after some amount of Absorption. | ||
+ | |||
+ | ==== soft and firm charging ==== | ||
+ | |||
+ | |||
+ | Solar is typically a moderate (or " | ||
+ | |||
+ | So while we can say with confidence that a 100Ah Li battery charged at 20A to 14.0v will be ~100% SoC, the same battery charged to 14.0v at 80A might only be at 75% SoC. The amp counter will probably help here during charging. | ||
+ | |||
+ | |||
+ | ===== estimating SoC while resting ===== | ||
+ | |||
+ | {{ http:// | ||
+ | A rested (no load), fully charged, unFloated lead battery will be 100% around 12.7v-12.8v; | ||
+ | |||
+ | The famous chart to the right is used to estimate SoC of a rested battery after a full charge. | ||
+ | |||
+ | A rested (no load), fully charged, unFloated lithium battery will be 100% around 13.5-13.6v. | ||
+ | |||
+ | As we will see below SoC-by-voltage will appear to be **artificially high during charging**((voltage rise)) and **artificially low during discharging**((voltage sag)). | ||
+ | |||
+ | |||
+ | |||
+ | |||
+ | |||
+ | |||
+ | |||
+ | |||
- | ===== estimatating SoC ===== | ||
==== SoC by specific gravity ==== | ==== SoC by specific gravity ==== | ||
Line 47: | Line 91: | ||
* intermittent heavier loads that leave the system with measured >=12.2v when that load is removed | * intermittent heavier loads that leave the system with measured >=12.2v when that load is removed | ||
- | The more challenging task is judging | + | ===== estimating SoC while discharging ===== |
+ | |||
+ | The more challenging task is judging | ||
+ | |||
+ | Consider this chart for Trojan FLA batteries: | ||
{{ https:// | {{ https:// | ||
Line 62: | Line 110: | ||
If the battery rebounds to the desired voltage then repeat to deeper discharge. | If the battery rebounds to the desired voltage then repeat to deeper discharge. | ||
- | An [[electrical: | + | |
+ | **Lithium batteries** also exhibit voltage sag under load but typically much less than AGM or especially FLA. | ||
+ | |||
+ | ===== estimating SoC while charging ===== | ||
+ | |||
+ | Similar to voltage sag during discharge, batteries exhibit voltage //surge// or //rise// during charging. | ||
===== partial state of charge ===== | ===== partial state of charge ===== | ||
This section [[electrical: | This section [[electrical: | ||
+ | |||
+ | ===== effect of DoD on lead battery life ===== | ||
+ | |||
+ | How deeply one regularly discharges lead-chemistry batteries will have a **direct effect on how long the battery bank will last**.((Banks are typically replaced when they have lost 20% of their capacity)) | ||
+ | |||
+ | |||
+ | The **most common discharge limit for deep cycle batteries is 50% DoD**. | ||
+ | |||
+ | Based on the following data on the Trojan T-105: | ||
+ | * lowest cost per Ah happens at 30% DoD | ||
+ | * longest life happens at 20% DoD | ||
+ | * least battery weight happens at 80% DoD | ||
+ | so make your DoD decision based on what is most important to you. | ||
+ | |||
+ | | | **T105 Ah**| | **Cost**| | ||
+ | | | 225| | $260.00| | ||
+ | | | | | | | | | | | | ||
+ | | | | | | | | | | | | ||
+ | | | | | | | | | | | | ||
+ | | **DoD**| | ||
+ | | 10| 90| 22.5| | | | | | | | ||
+ | | 20| 80| 45| 3000| 135| $1.93| | ||
+ | | 30| 70| 67.5| 2250| 151.875| | ||
+ | | 40| 60| 90| 1450| 130.5| | ||
+ | | 50| 50| 112.5| | ||
+ | | 60| 40| 135| 1050| 141.75| | ||
+ | | 70| 30| 157.5| | ||
+ | | 80| 20| 180| 800| 144| $1.81| | ||
+ | One can choose to [[electrical: | ||
+ | |||
===== lithium SoC ===== | ===== lithium SoC ===== | ||
Lithium chemistries have very flat voltage curves, making it notoriously difficult to gauge SoC by voltage. | Lithium chemistries have very flat voltage curves, making it notoriously difficult to gauge SoC by voltage. |