User Tools

Site Tools


opinion:frater_secessus:self-heated_lifepo4

Differences

This shows you the differences between two versions of the page.

Link to this comparison view

Both sides previous revision Previous revision
Next revision
Previous revision
Last revision Both sides next revision
opinion:frater_secessus:self-heated_lifepo4 [2023/09/03 16:07]
frater_secessus [how to think about the decision]
opinion:frater_secessus:self-heated_lifepo4 [2023/10/17 15:13]
frater_secessus [how the approaches work]
Line 9: Line 9:
      * self-heated:   easier      * self-heated:   easier
      * DIY:  more control, more charging under certain conditions, usually cheaper      * DIY:  more control, more charging under certain conditions, usually cheaper
 +  * in practice, warming is combined with other forms of protection:  BMS low temp charging shutoff, solar or DC-DC low temp charging cutoff, etc.(("belt and suspenders" approach)) 
 +===== how the approaches work =====
  
 +**Self-heated batteries**
  
 +  - sense ~freezing temps 
 +  - shut off charging((normal BMS shutoff))
 +  - allow incoming power only to the internal heaters, typically ~60w
 +  - when cell temps are >freezing charging is re-enabled
 +  - optional:  heating may continue until some warmer setpoint, typically 40F-50F when this feature is utilized
 +
 +This means //warming only happens when charging is present// This may or may not be what you want. 
 +
 +
 +**DIY warming solutions**
 +
 +  - use an external temperature controller and temperature probe
 +  - use the lowest-wattage warming mat practical for conditions((for gentlest, most-even heating))
 +  - and turn the mat on/off with the controller
 +
 +This means //warming happens whether or not charging is present// This may or may not be what you want. 
 +  
 ===== when it's a wash ===== ===== when it's a wash =====
  
  
-With "soft" charging like a small solar setup it's a wash.  a matter of preference and cost.   +With "soft" charging like a small solar setup it's a wash.  a matter of preference and cost.   But in some specific use cases one approach might work better. 
  
  
-===== perfect storm for self-heated batteries =====+===== when self-heated might be preferable ===== 
 + 
 +When you want a packaged solution. 
 + 
 +If you run your bank very low habitually((stop doing that!)) and the warming load is enough to trigger BMS discharge shutdown.  This problem does not occur with self-heated because heating only runs when charging is present.  
 + 
 + 
 +===== when DIY warming might be preferable ===== 
 + 
 +==== robust charging ==== 
  
 With robust charging (alternator and/or bigger solar) there can be charging opportunities lost with self-heated batteries in freezing conditions.   With robust charging (alternator and/or bigger solar) there can be charging opportunities lost with self-heated batteries in freezing conditions.  
  
-Imagine +Imagine the following scenario
  
-* freezing overnights followed by a half-hour drive in the morning with a 30A DC-DC.  +  * freezing overnights followed by a half-hour drive in the morning with a 30A DC-DC.  
-* a battery with warming pad that consumed 60Wh overnight to stay above freezing, vs +  * a battery with warming pad that consumed 60Wh overnight to stay above freezing, vs 
-* a self-heating battery that is below freezing in the morning+  * a self-heating battery that is below freezing in the morning
  
 The externally warmed bank accepts current immediately and takes **15Ah of recharge**.  So after recouping the 60Wh used overnight it's **net +132Wh**. The externally warmed bank accepts current immediately and takes **15Ah of recharge**.  So after recouping the 60Wh used overnight it's **net +132Wh**.
Line 33: Line 63:
 With 50A charging it's 260Wh net vs 107Wh net. . With 50A charging it's 260Wh net vs 107Wh net. .
  
-If one was charging by alternator only and only driving to/from work while stealthing in freezing weather it's conceivable the self-heated batt would get *never get charged at allbecause it wouldn't have time to get out of the heating phase.+If one was charging by alternator only and only driving to/from work while stealthing in freezing weather it's conceivable the self-heated batt would get //never get charged at all// because it wouldn't have time to get out of the heating phase. 
 + 
 +==== specific configurations ====
  
 +You may want more control over the temperature setpoints.  
  
-===== perfect storm for DIY warming =====+Note from Secessus:  "since reading [[https://diysolarforum.com/threads/why-you-cannot-charge-lifepo4-below-0-degrees-celsius.2912/page-2#post-199774|this cell spec sheet data]] I keep my bank at toasty 50deg F."
  
  
-You run your bank very low habitually (don't do that) and the warming load is enough to trigger BMS discharge shutdown.   
  
 ===== how to think about the decision ===== ===== how to think about the decision =====
Line 46: Line 78:
  
   * how much charging would I miss out on because the bank is taking only 60w to run the heaters instead of taking everything I can throw at it?; and   * how much charging would I miss out on because the bank is taking only 60w to run the heaters instead of taking everything I can throw at it?; and
-   * how does this compare to the Wh required to keep the bank above freezing when no charging is present? +  * how does this compare to the Wh required to keep the bank above freezing when no charging is present? 
-   * do I need greater configurability than the built-in heater allows?+  * do I need greater configurability than the built-in heater allows
 +  * do I have the interest or ability to DIY?
  
 ===== further reading ===== ===== further reading =====
opinion/frater_secessus/self-heated_lifepo4.txt · Last modified: 2023/10/17 15:13 by frater_secessus