User Tools

Site Tools


electrical:generator

This is an old revision of the document!


Generators

images-na.ssl-images-amazon.com_images_i_510ud0js72l._ac_us218_.jpg A generator is a device that creates electricity from some other form of energy. In RV terms this usually means a gasoline powered generator, but they can also run on propane or diesel. Residential generators sometimes run on natural gas.
Note: in some areas solar setups and wind turbines are also called “generators”. Portable “power stations” are sometimes, inaccurately, marketed as solar generators.

The most common built-in generator found in RVs is the Onan, now owned by Cummins.

The most common higher end portable generators are the Honda EU2000-series, inverter generator with Yamaha a close second.

The lower end is dominated by Champion and other open-frame, non-inverter “contractor” gennies, which are loud but cost 1/3rd as much as Japanese models. Recently some inexpensive inverter generators have come to market, including the Harbor Freight Predator line. Lower-end generators may not be intended for repair, and repair parts may not be available.

Some have reported success with Honda and Yamaha clones like Wen (tested) or Kipor.

inverter generators

Inverter generators adjust engine output to meet power demand. This can mean at lower power levels inverter generators can be considerably quieter than older technologies. At maximum rated power the noise difference between inverter and non-inverter gennies may not be as great.

etiquette

It is common to leave generators quiet in times of darkness, and to not run them when close to other campers.

charging batteries

Generators are not particularly well-suited to charging lead-acid batteries (flooded, sealed, AGM, etc) on their own. They work best in combination with solar; the generator handles Bulk charging and solar handles the long-duration, low-current Absorption and Float stages.

[Alternator charging + solar can do the same thing for about $950 less – Secessus]

If the generator is being used for some other purpose then by all means add on battery charging. But running a generator for hours at 5% capacity only for charging is not optimal.

Generators are well suited to charging lithium-chemistry batteries as that type can take current at all points of charging.

efficient use

Generators generally have a minimum amount of wattage they can produce. This means that until you hit that minimum multiple loads can be run for “free”, speaking in terms of fuel consumption.

An example of an efficient use would be:

  1. start the generator in the morning when batteries are most depleted and can take the most current
  2. use your heavy loads at the same time as possible, up to the practical limit of the generator
  3. shut the genny down after the battery bank reaches Vabs and let solar handle Absorption and Float stages

specs

In general, generators with higher wattage ratings will be bigger, heavier, use more fuel, and cost more. They also tend to make most efficient use of fuel when fully loaded. Because of this, one rule of thumb is to get the smallest generator that will meet your needs.

Generators are often rated (and named) after their peak wattage output. For example, the small Honda eu1000i is a 1000w max inverter generator rated at 900w continuous.

Not all generators put out Pure Sine Wave (PSW) 120vac; some are Modified Sine Wave (MSW). See the inverter article for more info on PSW vs MSW.

THD (“total harmonic distortion”) is a spec describing the “cleanliness” of the sine wave output. Delicate or picky electronics may require ≤5% THD.1)

Runtime means how long the generator will run a single fueling.

Some generators can be paralleled, or combined to make more power in tandem.

Fuel injected generators may offer better performance at altitude extremes.

maintenance

Generators typically require maintenance after initial break-in and every X hours thereafter. Read the manual for specific instructions, but recommendations are typically for oil changes after the first two hours then every 20 hours thereafter. The frequency of oil changes make make it worthwhile to watch oil-changing videos for each model under consideration. Remember to carry spare oil and a way to transport used oil to a recycle or disposal point.

Depending on design, air filters will require cleaning or replacement.

Fuel left in an unused generator can leave residue resulting in poor (or no) performance. It is common to run the fuel out of the genny at the end of the camping season to avoid this residue. Fuel stabilization products like Sta-Bil may help reduce the problem.

further reading

electrical/generator.1640898744.txt.gz · Last modified: 2021/12/30 16:12 by frater_secessus